Click here for this document as a PDF File

 

ELECTRAETCH

Material Safety Data Sheet


SECTION I - IDENTITY


Hazardous - YES

UNITED Static Control Products Inc

4878 Lake View Cir

Colorado City, CO 81019

Health                     

2
Flammability 0
Reactivity 1
Personal Protection C

4 = Most Hazardous

 

Telephone Number for Information

(719) 676-3928

Date Prepared Emergency Phone Number

03/18/09 1-800-255-3924 or Poison Center

Prepared By T. Pitrolffy


SECTION II - HAZARDOUS INGREDIENTS


Hazardous Components PEL TWA STEL Other Limits % (optional)
  CAS Reg # mg/m3 mg/m3

mg/m3

ceiling

 
*SULFURIC ACID #7664-93-9  1  1 3   < 5
*HYDROGEN CHLORIDE #7647-01-0 N.A. N.A. N.A. 7 < 20

   

*LISTED CHEMICAL SUBJECT TO REPORTING REQUIREMENT OF SCT.313 OF TITLE III.


SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS


Boiling point - 210F Specific Gravity (Water=1) - 1.04
Vapor Pressure (mm Hg) - 18.5 Melting Point - N.A.
Vapor Density (air=1) - 1.1 Evaporation Rate (Butyl Acetate=1) -0.2
Viscosity (CPS) - 5 Decomposition Temperature - NA.
Auto Ignition Temp. - NA Solubility in Water -COMPLETE
pH - 1.5 +/-  
Appearance and Odor -BLUE LIQUID WITH WINTERGREEN FRAGRANCE

SECTION IV - FIRE AND EXPLOSION HAZARD DATA


Flash Point - N.A. Flammable Limits
  LEL - N.A. UEL - N.A.
Extinguishing media - WATER
Fire Fighting Procedure - COOL CONTAINERS WITH WATER

Fire and Explosion Hazards - NON FLAMMABLE, BUT MAY REACT WITH MOST METALS

ON LONG CONTACT, WITH THE POSSIBLE EVOLUTION OF HYDROGEN


SECTION V - REACTIVITY DATA


Stability - STABLE

Conditions to Avoid - N.A.

Incompatibility - ALKALINE, CHLORINE AND CELLULOSE BASED MATERIALS

Hazardous Decomposition or Byproduct - HYDROGEN CHLORIDE GAS

Hazardous Polymerization - WILL NOT OCCUR

Conditions to Avoid - N.A.


SECTION VI - HEALTH HAZARD DATA


Routes of entry:

Inhalation - YES Skin - YES Ingestion - YES

Health Hazards-Acute: CAUSES SEVERE CHEMICAL BURNS TO EYES, SKIN AND MUCOUS

MEMBRANES. CHRONIC: CHEMICAL BURNS AND/OR ULCERATION OF SKIN, MAY PERMANENTLY

DAMAGE EYES. TARGET ORGANS: EYES, RESP. SYS., UPPER GI. TRACT, SKIN

Carcinogenicity: NO

NTP - N.A. IARC Monographs - N.A. OSHA Regulated - NO

Signs and Symptoms of Exposure - REDNESS, IRRITATION OF EYES, SKIN OR

MUCOUS MEMBRANES

Medical Conditions Aggravated - SENSITIZED SKIN

Emergency and First Aid Procedures - IMMEDIATELY WASH CONTACT AREAS (EYES)

WITH LARGE QUANTITIES OF WATER FOR 15 MINUTES.

INGESTION: DRINK LARGE AMOUNTS OF WATER OR MILK, CALL PHYSICIAN.


SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE


Steps to be Taken in Case Material is Released or Spilled - DIKE AND

COLLECT MATERIAL INTO PLASTIC CONTAINER. WATER RINSE AND DRAIN, FLUSH

SMALL AMOUNTS. NEUTRALIZE WITH SODA, ASH OR LIME. (BIODEGRADABLE)

Waste Disposal Method - DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL

HAZARDOUS WASTE REGULATIONS; USE SANITARY LANDFILL.

EPA WASTE NO. D002

Precautions to be Taken in Handling and Storage -

USE ADEQUATE VENTILATION. DO NOT MIX WITH OTHER CHEMICALS.

AVOID PROLONGED CONTACT. KEEP FROM FREEZING AND EXCESSIVE HEAT

Other Precautions - STORE IN SECURE AREA. AVOID FOOD OR FEED CONTAMINATION.

RINSE EMPTY CONTAINERS BEFORE DISPOSAL. KEEP OUT OF REACH OF CHILDREN !


SECTION VIII - CONTROL MEASURES


Respiratory Protection - USE IN WELL VENTILATED AREA, FOLLOW DIRECTIONS,

AVOID INHALING MIST.

Ventilation Local Exhaust - RECOMMENDED

Mechanical - N.A.

Special - N.A.

Other - ASSURE FRESH AIR CIRCULATION.

Protective Gloves - REQUIRED: RUBBER, PLASTIC

Eye Protection - REQUIRED: SAFETY GLASSES, GOGGLES

Other Protection - RECOMMENDED: RUBBER OR PLASTIC APRON, EYE WASH

Work/Hygienic Practices - DO NOT EAT, DRINK OR SMOKE NEXT TO MATERIAL.

WASH HANDS/FACE AFTER WORK.


SECTION IX - TRANSPORTATION 49 CFR


Unit Cont. - 55,30,5,1 GAL.,1 QT PLASTIC Report Qty. (Lbs) - NA

OSHA - IRRITANT Labels - CORROSIVE

DOT - HAZARDOUS /X/ CORROSIVE LIQUID, PACKAGING GROUP II

UN - HAZARDOUS /X/ CORROSIVE LIQUID, PACKAGING GROUP II

UN/DOT: Corrosive liquid, acidic, inorganic, n.o.s.

(Contains Hydrochloric Acid) 8, UN3264, PG II

1 quart=limited quantity (49 CFR 173.154)


The information herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of these data or results to be obtained from use thereof. Essentially similar to OSHA form # 174 Vendor assumes no responsibility for injury to vendee or third person proximately caused if reasonable safety procedures are not adhered to as stipulated in the data sheet. Additionally, vendor assumes no responsibility for injury to vendee or third persons caused by abnormal use of the material even if reasonable safety procedures are followed. Further more, vendee assumes the risk in use of the material.